Foley Equipment Contact

2012 CATERPILLAR 777G

Loading...

MINING OFF HIGHWAY TRUCK

Price: $Call
Hours: 14283
Catalog Number: 1016358
Serial Number: RDR00164
Location: Birmingham, AL
Rating: GOOD

Contact Info
Foley Equipment
Phone: (316) 943-4211
Email Us
Make Offer

Features

  • AIR CONDITIONER
  • PAYLOAD MEA SYS
  • RETARDER
  • VIMS
  • PRODUCT LINK
  • LIGHTING
  • ULTRA LOW SULFUR DIESEL FUEL
  • PRODUCT LINK

Condition

New
New
Very Good
Very Good
Good
Good
Fair
Fair
Poor
Poor

GENERAL CONDITION

Body Good
Frame Good
General Good
Machine Starts and is Operable No - BATTERIES DEAD
S.O.S. (All Compartments) No
ET Download Available Yes
VIDS/VIMS Download Available Yes
Tires are Aired Up and Drivable Yes

GENERAL APPEARANCE

Hydraulic Tank Fair
RETAINER MISSING FROM FILL SCREEN
A-Frame RAX Fair
MISSING RETAINER BOLT FROM PIN
Frame Good
Steps / Ladder Fair
FRONT STEPS ON EACH SIDE HAVE BEEN ALTERED AND RIGHT STAIRWAY BENT NEEDS REPAIR
Cab Overall Condition Good
Tin Ware Fair
HOOD MOUNT BOLT BROKEN OFF AND NEEDS REPLACED
Paint Good
Bumper Good
Fenders Fair
RT FRONT FLAIR BUSTED, MUD FLAP TURN BEHIND, LEFT FRONT
Radiator Grill & Shroud Good
Grab Irons Fair
RIGHT FRONT LOOP BENT NEEDS REPAIR
Crankcase Guard / Battery Box Fair
ENGINE BOTTOM GUARDS BENT UP NEED REPAIR
Main Frame Welds Good
Decal Appearance Good
Fuel Tank Fair
BOTTOM OF TANK BENT, BREATHER BUSTED AND FAST FILL DUCT COVER MISSING
Draw Bar Good

SAFETY ITEMS

Brakes Functioning Yes
Back Up Alarm Functioning Yes
Horn Good
Glass / Mirrors Fair
ONE DAMAGED MIRROR MOUNT, 3 MISSING RUBBER TRIM
ROPS Good
Parking Brake Good
Seat Belt Fair
SEAT BELTS DATED MAY 2012
Notes: GLASS BREAKING HAMMER MISSING; AUTO LUBE SYSTEM PUMP MOUNTING BOLTS LOOSE AND ONE BROKE IN GREASE LEVEL SENSOR AND WIRING NEEDS TIED UP.

GAUGES, OPERATOR STATION, CONSOLE

Floor Mats Fair
NEED CLEANED
Interior Lights Good
Seat Cushion / Arm Rest Good
Windshield Wipers Fair
NEED FRONT WIPER
Switches Good
Dash Console Fair
BED RAISE & LOWER FILM BUSTED
Gauges Good
Air Conditioner Good
EMS Panel / Warnings Good
Heater Good
Door Latches & Hinges Fair
LEFT DOOR LATCH COVER MISSIGN DOOR STOP BUSTED
Current O&MM No
Notes: PRODUCT LINK ANTENNA WIRES DAMAGED

ENGINE

Air Cleaners Fair
AIR FILTERS (PRIMARY) DIRTY; PRECLEANER CAPS LOOSE
Turbocharger Good
Other Fair
INSIDE CAB FILTER DIRTY AND OUTSIDE FILTER FULL OF DIRT
Fuel System Good
Governor Good
Engine Supports Good
Notes: LEFT CATWALK, HANDRAILS, AND MUD FLAPS FLAT ON MACHINE
Knocking No
Fuel Leaks No
Engine Oil Level Full Yes
Apparent Other Engine Damage No
Compression in Radiator No
Blow By No
Oil filter Cut and Inspected No
Oil Leaks No
Water in Oil No
Smoke (B/D/L/W) LITTLE OR NO SMOKE
Oil Pressure (H/L/N) NORMAL

COOLING SYSTEM

Leaks No
Oil in Anti-Freeze No
Belts / Pulleys Good
Coolers Good
Fan Drive Fair
HOSE #372-7570 LEAKING
Water Pump(s) Good
Radiator Fair
NEEDS PRESSURE WASHED
Fan Good
Hoses & Tubes Fair
BRAKE COOLER HOSES ON COOLER LEAKING OF REAR BRAKE COOLER TUBES MISSING DUST CAP

ELECTRICAL, STARTING AND CHARGING SYSTEM

Lighting Fair
BAD CONNECTION ON RIGHT SIDE MARKER & TAIL LIGHT
Wiring Good
Alternator Good
Starter Electric Good
Batteries / Cables Fair
BATTERIES DEAD, HOLD DOWNS BENT AND BOX FULL OF DIRT
Notes: GROMMET FOR WIRING ON RIGHT SIDE OUT OF PLACE BEHIND GRILL

TORQUE CONVERTER

Torque Converter Good
Controls Good
Leaks Fair
SIGHT GLASS LEAKING, OIL LEVEL SENSOR DAMAGED, ONE TUBE CRUSHED AND BOTH LEAKING
Universal Joints Good
Magnetic Screens Inspected No

TRANSMISSION

Mag Screens Checked No
Transmission Good
Controls Fair
SHIFT LEVER AND FILM BROKEN
Universal Joints Good
Retarder Good
Leaks Fair
HOSE# 317-7332 & 369-8217: 342-6583: 359-1433& CLIP (NEED CLIP)

STEERING

Arm Center (Steering Linkage) Fair
BEARINGS AND PIN WORN
Steering Tank Fair
RELIEF VALVE BUTTON MISSING AND NEEDS REPLACED & SCREEN MISSING SEAP RING
Steering Cylinder Fair
LEFT INSIDE GREASE CAP MISSING SNAP RING RIGHT INSIDE CYCLE HOSE FITTING LEAKING
Steering Valves / Pumps Good
Front Axle Fair
RIGHT SIDE SPINDLE DUO CONE SEAL LEAKING

BRAKE

Control Valves Good
Pumps Good
Lines / Tubes Fair
FILTER BOLT LEAKING , RT AND LT SERVICE & PARK BRAKE HOSES LEAKING
Notes: BRAKE OIL COOLER CRUSS OVER SUCTION HOSES LEAKING & LEFT TOP HOSE

AXLE ASSEMBLIES

Right Rear Suspension Cylinder Hours NEED TO REPOSITION BOOT & CLAMPS
Left Rear Suspension Cylinder S/N BOTTOM GREASE LINE NEEDS REPLACED
Right Rear Suspension Cylinder S/N BOTTOM GREASE LINE NEEDS REPLACED
Right Front Suspension Cylinder S/N NO BOOT OR CLAMP
Left Front Suspension Cylinder S/N NO BOOT OR CLAMP
Left Rear Suspension Cylinder Hours NEEDS NEW BOOT AND CLAMPS
Axle Housing Fair
OIL LEVEL SENSOR WIRES TAPED UP
Wheel Lugs & Rims Good
Differential Fair
BREATHER NEEDS REPLACED & REPOSITIONED
Right Final Drive Fair
DUE CONE SEAL SEEPING
Left Final Drive Good
Left Rear Final Mag Plug Checked No
Right Rear Final Mag Plug Checked No
Differential Mag Plug Inspected No

TRUCK BODY & CYLINDERS

Side Boards Yes - WORN THROUGH AT REAR BOTH
Heated Body No
External Ribs and Stringers Fair
SEVERAL CRACKS
Hinge Pins and Bushings Fair
WEAR STEPS ON BEARINGS & PINS & NEEDS SHIM & SPACERS
Body Side Walls Good
Mud Flaps Fair
ONE FLAP PLATE BENT
Bed Liner Fair
LEFT SIDE WORN THROUGH AT REAR
Body Floor Fair
WORN THROUGH ON REAR PLATE
Mounting Brackets Good
Body Canopy Fair
ROCK GUARDS HAVE BEEN REMOVED
Hydraulic Hoses Fair
TWO NON CAT HOSES ON HOIST CUT AND CLIP BAD HYD PUMP SUCTION HOSE LEAKING
Lift Cylinders Fair
LEFT TOP GREASE LINE CUT
Rock Kickers / Flaps Good
Pads Good
BAD ON GROUND
Notes: BED UP SENSOR BRACKET BENT

TIRES

Notes: AUTO LUBE PUMP OIL SUPPLY HOSE# 359-5006 IS LEAKING & ADJ COVER MISSING FROM VALVE.; GROMMETS MISSING FROM REAR WHEELS AND ALL VALUE STEM CAPS MISSING

COMMENTS, MISC. REPAIRS, GENERAL REMARKS

POSSIBLE BROKEN BOLT IN EXHAUST PIPE MOUNT
BED EXHAUST COVER BOLTS LOOSE
ONE FIRE EXTINGUISHER MISSING & BRACKET BENT UP ON LEFT CAT WALK
SOFTWARE NEEDS UPDATING & CHECKED TO SEE IF FAULT CODES GO AWAY